York F*FP Manual de instalación descargar pdf (Pagina 1)

404912-UIM-B-0209

SINGLE PIECE

AIR HANDLERS

MODELS: F*FP

INSTALLATION MANUAL

ISO 9001

Certified Quality

Management System

LIST OF SECTIONS

SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

SPECIFIC SAFETY RULES AND PRECAUTIONS . . . . . . . . . . . . . . .2

SAFETY REQUIREMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

GENERAL INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

LIMITATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

CLEARANCES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

LOCATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

HORIZONTAL DRAIN PAN CONVERSION . . . . . . . . . . . . . . . . . . . .3

DUCT CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

AIR FILTERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

SUSPENSION KITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

COIL METERING DEVICES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

REFRIGERANT LINE CONNECTION . . . . . . . . . . . . . . . . . . . . . . . . 6

ELECTRIC HEATERS AND OPERATING CONTROLS . . . . . . . . . . 6

LOW VOLTAGE CONTROL CONNECTION . . . . . . . . . . . . . . . . . . . 7

LINE POWER CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

BLOWER SPEED CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . 7

DRAIN CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

COIL CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

CONDENSATE DRAINS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

LIST OF FIGURES

Plenum Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

Typical Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

Filter Access & Drain Pan Conversion / Coil Baffle . . . . . . . . . . . . . . .4

Dimensions & Duct Sizes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

Typical Horizontal Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

TXV Bulb Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

Bulb Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Control Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Electric Heaters in Horizontal Configuration - Right Hand Air Flow . . 7

Line Power Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Blower Speed Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Cooling Models with Electric Heat Wiring . . . . . . . . . . . . . . . . . . . . . 14

Single Stage Heat Pump Control Wiring . . . . . . . . . . . . . . . . . . . . . . 14

LIST OF TABLES

Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

Installed TXV Sizes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

Physical and Electrical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

Electrical Data - Cooling Only (50 & 60 Hz) . . . . . . . . . . . . . . . . . . . . .8

Conversion Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

Electrical Data - 1 Ø - 208/230-1-60 . . . . . . . . . . . . . . . . . . . . . . . . . .9

Electrical Data - (For Single Source Power Supply) -

Copper Wire 1 Ø - 208/230-1-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

Electrical Data - (For Multi-Source Power Supply) -

Copper Wire 1 Ø - 208/230-1-601 . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Electrical Data - 3 Ø - 208/230-3-60 . . . . . . . . . . . . . . . . . . . . . . . . . 11

Electrical Data - (For Single Source Power Supply) -

Copper Wire 3 Ø - 208/230-3-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Airflow Data for 230 Volt - Heat Pump Models . . . . . . . . . . . . . . . . . 12

Airflow Data for 208 Volt - Heat Pump Models . . . . . . . . . . . . . . . . . 13

Troubleshooting Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

SAFETY

This is a safety alert symbol. When you see this symbol on

labels or in manuals, be alert to the potential for personal

injury.

Understand and pay particular attention to the signal words DANGER,

WARNING, or CAUTION.

DANGER indicates an imminently hazardous situation, which, if not

avoided, will result in death or serious injury

WARNING indicates a potentially hazardous situation, which, if not

avoided, could result in death or serious injury

CAUTION indicates a potentially hazardous situation, which, if not

avoided may result in minor or moderate injury.

It is also used to

alert against unsafe practices and hazards involving only property dam-

age.

Improper installation may create a condition where the operation of

the product could cause personal injury or property damage.

Improper installation, adjustment, alteration, service or mainte-

nance can cause injury or property damage. Refer to this manual

for assistance or for additional information, consult a qualified con-

tractor, installer or service agency.

This product must be installed in strict compliance with the installa-

tion instructions and any applicable local, state, and national codes

including, but not limited to building, electrical, and mechanical

codes.

1 2 3 4 5 6 ... 15 16

Indice de contenidos

Pagina 1 - INSTALLATION MANUAL

404912-UIM-B-0209SINGLE PIECE AIR HANDLERSMODELS: F*FPINSTALLATION MANUALISO 9001Certified QualityManagement SystemLIST OF SECTIONSSAFETY . . . . . .

Pagina 2

404912-UIM-B-020910 Johnson Controls Unitary Products* May be 0 (no breaker) or 1 (with breaker).TABLE 7: Electrical Data - (For Single Source Power S

Pagina 3

404912-UIM-B-0209Johnson Controls Unitary Products 11TABLE 9: Electrical Data - 3 Ø - 208/230-3-601Models F*FPHeater2ModelMax. Static& Min. CFMTot

Pagina 4

404912-UIM-B-020912 Johnson Controls Unitary ProductsAll F*FP series air handler units are UL Listed up to 1/2" w.c. external static pressure, in

Pagina 5 - COIL METERING DEVICES

404912-UIM-B-0209Johnson Controls Unitary Products 13TABLE 12: Airflow Data1 for 208 Volt - Heat Pump Models1. Includes Return Air Filter and Largest

Pagina 6 - CONTROLS

404912-UIM-B-020914 Johnson Controls Unitary ProductsNOTES:1. “Y” Terminal on Air Handler Control Board must be connected for full CFM and application

Pagina 7 - BLOWER SPEED CONNECTIONS

404912-UIM-B-0209Johnson Controls Unitary Products 15DRAIN CONNECTIONSAll drain lines should be trapped a minimum of three inches, should bepitched aw

Pagina 8

Pagina 9

404912-UIM-B-02092 Johnson Controls Unitary ProductsSPECIFIC SAFETY RULES AND PRECAUTIONS1. Install this air handler only in a location and position a

Pagina 10 - 404912-UIM-B-0209

404912-UIM-B-0209Johnson Controls Unitary Products 36. Proper electrical supply must be available.7. If unit is located in an area of high humidity (i

Pagina 11

404912-UIM-B-02094 Johnson Controls Unitary Products FIGURE 3: Filter Access & Drain Pan Conversion / Coil BaffleFILTER3B - SIDE VIEW"S"

Pagina 12

404912-UIM-B-0209Johnson Controls Unitary Products 5DUCT CONNECTIONSNOTE: The electric heat accessory should be installed before the sup-ply air duct

Pagina 13

404912-UIM-B-02096 Johnson Controls Unitary ProductsThe TXV is bolted into the coil assembly of this Air Handler unit at thefactory. The temperature s

Pagina 14 - Air Handler Control Wiring

404912-UIM-B-0209Johnson Controls Unitary Products 7LOW VOLTAGE CONTROL CONNECTIONThe 24 volt power supply is provided by an internally wired low volt

Pagina 15 - CONDENSATE DRAINS

404912-UIM-B-02098 Johnson Controls Unitary ProductsTABLE 3: Physical and Electrical DataModels F*FP 024 030 036 040Blower - Diameter x Width 10 x 6 1

Pagina 16 - 5005 York Drive

404912-UIM-B-0209Johnson Controls Unitary Products 9* May be 0 (no breaker) or 1 (with breaker).TABLE 6: Electrical Data - 1 Ø - 208/230-1-601Models F

Comentarios a estos manuales

Sin comentarios

York F*FP Manual de instalación Pagina 1

Busca en linea o descarga Manual de instalación para Acondicionadores de aire del sistema de división York FFP. York FFP Installation manual Manual de usuario

Indice de contenidos

Comentarios a estos manuales

York F*FP Manual de instalación Pagina 1

Busca en linea o descarga Manual de instalación para Acondicionadores de aire del sistema de división York F*FP. York F*FP Installation manual Manual de usuario

Indice de contenidos

Comentarios a estos manuales

Relacionado con productos y manuales para Acondicionadores de aire del sistema de división York F*FP

Busca en linea o descarga Manual de instalación para Acondicionadores de aire del sistema de división York FFP. York FFP Installation manual Manual de usuario